Buzzforbrains

There is a TSB for the mirror to be replaced and it has helped some. FORD: 2007 Expedition LINCOLN: 2007 Navigator ISSUE: Some 2007 Expedition and Navigator vehicles built before 05/07/2007 may exhibit wind noise around the exterior driver and/or passenger doors. This may be most noticeable near the A-pillar area of the door. ACTION: Follow the Service Procedure steps to correct the condition. SERVICE PROCEDURE NOTE: IF THE VEHICLE BUILD DATE IS ON OR AFTER 5/07/2007, THIS TSB DOES NOT APPLY. CONTINUE WITH NORMAL WORKSHOP MANUAL DIAGNOSTICS. Tape the trailing edge of the mirror sail down to the front window glass from the tip of the mirror sail to the belt molding. If the noise goes away, replace the mirror on the effected side. Both mirrors do not have to be replaced. If the noise does not go away, continue with normal Workshop Manual (WSM), Section 100-04 diagnostics. PART NUMBER PART NAME 8L1Z-17682-AA Mirror - Expedition-Passenger - Power/Heated Convex - Middle Eastern Countries 8L1Z-17682-BA Mirror - Expedition-Passenger - Power Heat/Memory 8L1Z-17682-CA Mirror - Expedition-Passenger - Power Heat/Memory - Middle Eastern Countries 8L1Z-17682-DA Mirror - Expedition-Passenger - Power/Heated Convex 7L1Z-17682-EA Mirror - Expedition-Passenger - Power 7L1Z-17682-FA Mirror - Expedition-Passenger - Power - Middle Eastern Countries 8L1Z-17682-GA Mirror - Navigator-Passenger - Power Heat/Memory Power Fold / Expedition-Power Fold, Power Adjust 8L1Z-17682-HA Mirror - Expedition-Passenger - Power Fold/Power Adjust - Middle Eastern Countries 8L7Z-17682-AA Mirror - Navigator-Passenger - Power Heat/Memory Power Fold 8L7Z-17682-BA Mirror - Navigator-Passenger - Power Heat/Memory Power Fold - Middle Eastern Countries 8L1Z-17683-AA Mirror - Expedition-Driver - Power/Heated 8L1Z-17683-BA Mirror - Expedition-Driver - Power/Memory/Heat 7L1Z-17683-CA Mirror - Expedition-Passenger - Power Heat/Memory - Middle Eastern Countries 8L1Z-17683-DA Mirror - Navigator-Drivers - Power Heat/Memory/Power Fold / Expedition-Power Fold/Power Adjust 8L7Z-17683-AA Mirror - Navigator-Drivers - Side Power Heat/Memory/Power Fold WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part. OPERATION DESCRIPTION TIME 071615A 2007 Expedition/Navigator: Replace One Mirror, Includes Time To Road Test To Verify Concern (Do Not Use With 17682C, 23943A) 0.7 Hr. 071615B 2007 Expedition/Navigator: Replace Both Mirrors, Includes Time To Road Test To Verify Concern (Do Not Use With 17682C, 23943A) 1.1 Hrs. 071615C 2007 Expedition/Navigator: Extra Time To Paint One Mirror, This Labor Operation Should Be Claimed With Labor Operation A (Do Not Use With P101, P17) 1.0 Hr. 071615D 2007 Expedition/Navigator: Extra Time To Paint Both Mirror, This Labor Operation Should Be Claimed With Labor Operation B (Do Not Use With P101, P17) 1.5 Hrs. DEALER CODING BASIC PART NO. CONDITION CODE 17682 07 -------------------------------------------------------------------------------- NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by "do-it-yourselfers". Do not assume that a condition described affects your car or truck. Contact a Ford, Lincoln, or Mercury dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates. The most recent information is available through Ford Motor Company's on-line technical resources. Copyri

For petes sake take it in! Make sure you drive with the tech so they can see it happen. Too dangerous not to fix this.

$20 shipped.

Well You already blew money on throwing parts at it, whats another $90?

Thanks for posting this. I never new I had this option! I want the auto wipers that sense water!

Dont get it.

Couldn't agree more. Want a pin # buy some shares or marry an employee. Otherwise, forget it.

Really? You had good luck. In our fleet 3 out of the 5 truck with LS have needed clutchs replaced frequently. And the 2 trucks that did better saw more abuse.

Yeah your dealer wants you to buy a 2010.

And replace the clutch packs every 30K miles?

2018 maybe.

Can't have RSC and LS. End of story.

Sounds like master cylinder air leak.

Paint quality on new Fords is off topic? Petty? OK. Don't inspect your 2011 for paint issues, I am sure it will be fine... Oh, and if you do find some after you take delivery, don't post any threads about it. Want to stay on topic.

Yeah, I owned some Fords from the 80's and 90's. The clear coat failure was miserable. Now I don't think it's so much a problem of the material being used as it is the process. Thin base coats, improper prep on aluminum panels, etc.